Body TSB

TSB - Freedom Top - Header Seal - Water Leak In Area Of Dash

August 26th, 2008

TSB - Wind-Like Sound At Outer Ends Of The Sunrider Soft Top Windshield Header

January 15th, 2008

TSB - Rear Door Inside And Outside Handles Do Not Function

November 14th, 2007

TSB - Paint Repair - Etching

October 26th, 2007

TSB - Whistle-Like Sound Due To Gap Between Leading Edge Of Header Seal And Windshield Frame

August 29th, 2007

TSB - Windshield Frame Header Seal - Butyl Adhesive Squeeze-Out At Top Corners

August 29th, 2007

TSB - Rear Lower Corner Of Soft Top May Not Stay Tucked To Rail Retainer On Body

August 23rd, 2007

TSB - Rear Seat Back May Not Fold Due To Latch Release Cable Loose At Handle

June 28th, 2007

TSB - Wind-Like Sound At A-Pillar Of Windshield Frame

May 25th, 2007

OVERVIEW: This bulletin involves sealing the windshield frame underneath the reinforcement brackets.

TSB - Water Leak At A-Pillar Due To Windshield Header Seal Adhesive

May 24th, 2007

TSB - Difficulty Releasing Soft Top Plastic Edge Retainers From B-Pillar Area Of Door Frame

April 13th, 2007

OVERVIEW: This bulletin involves trimming material from a section of the plastic retainer, used to secure the edges of the soft top to the door frame, in the immediate area of the B-Pillar.

TSB - Oil Canning, Popping, or Thumping-Like Sound From Front Passenger Area During Body

February 24th, 2007

OVERVIEW: This bulletin involves creating two depressions in the front floor pan at the transmission tunnel area to reduce panel flex.

TSB - Modular Hard Top Freedom Panel Waterleaks

January 06th, 2007

OVERVIEW: This bulletin involves replacement of foam and/or butyl tape(s) and/or weatherstrips to eliminate Freedom Panel water leaks.

TSB - Front And/Or Rear Door Weatherseal Retention

October 26th, 2006

OVERVIEW: This bulletin involves procedures for adhering weatherseal to door frame.

TSB - Cracked Windshield

October 21st, 2006

DISCUSSION: Windshield cracks caused by an impact from a foreign object; (i.e. stone) are often difficult to identify. The following assessment should be used to verify the presence of an impact chip on the crack.

TSB - Soft Top Slaps Against Speaker Bar

October 21st, 2006

OVERVIEW: This bulletin involves installing foam padding to the top of the speaker bar.

TSB - Rear Door Inside And Outside Handles Do Not Function

October 03rd, 2006

OVERVIEW: This bulletin involves adjusting the door latch adjustment screw.

TSB - Exterior Lamp - Lens Fogging

September 27th, 2006

DISCUSSION: Some customers may report that on occasion, vehicle exterior lamp assemblies are fogged with a light layer of condensation on the inside of the lenses.

TSB - YES Essentials® Stain, Odor, & Static Resistant Fabric Care

August 09th, 2006

DISCUSSION: The premium cloth upholstery in the vehicles listed is the new YES Essentials® stain, odor, & static resistant fabric. YES Essentials® fabric is an easy-care material that repels and releases soil to maintain the like-new appearance.

TSB - Windshield Wiper Blade/Element Maintenance

March 08th, 2006

DISCUSSION: Windshield wiper blades/elements are frequently replaced unnecessarily. Because of the environmental conditions vehicles can be operated in, a film can build up on both the windshield and the windshield wiper elements that will cause poor cleaning/streaking of the windshield, and in some instances, a chattering condition as the wipers blades travel across the windshield.